技術參數

四川蓄電池叉車價格報價廠家介紹叉車蓄電池的液面與導線檢查

叉車蓄電池的由于是加水電瓶，需要日常檢查電解液是否足夠，保持蓄電池內部電解液液面高度。一般夏季1星期檢查1次，冬季2星期檢查1次。這個可以依靠液位顯示器體現，又或直接可以揭開蓋子目測，用半透明塑料作外殼的蓄電池，殼外即可看到內部液面高度，外殼上還有上、下2條標線，液面高度只要在這2條標線之間即可。用黑色塑料作外殼的蓄電池，檢查時要擰開加液蓋，可直接用眼睛觀察估計液面高度，也可用一小玻璃管插入蓄電池，用手指按住玻璃管上口，取出電解液進行檢查。正常情況下，電解液液面高度應高于極板10～15毫米。在起叉或者行走的時候，一旦感覺出現車輛無力，爬坡出現困難情況，經常檢查正、負極極樁與連接導線接頭之間的連結是否良好，叉車蓄電池正、負極極柱與連接導線之間一般用鐵螺絲作固定連接，電解液又很容易腐蝕螺絲螺母，使連接松動、接觸電阻增大，從而造成電機啟動無力或無法啟動。因此，平時要經常檢查該處是否松動并及時擰緊。此外，還有一個容易被忽略的地方，就是極樁與連接導線接頭之間的2個接觸表面是否有嚴重氧化或污垢，如有，則即使連接螺絲沒有松動，電流流過此處時電阻仍很大，照樣會造成起動機啟動困難或無法啟動。這時，應用刀片將2個接觸表面刮凈后再連接。連接好后，連接處表面最好涂些黃油或凡士林，以防受電解液的腐蝕和氧化。 

叉車蓄電池虧電時，要及時補充充電 平時，如發現燈光暗淡、喇叭聲沙啞、啟動無力等現象，說明蓄電池已嚴重虧電。虧電的蓄電池極板很容易被硫化，使蓄電池容量下降，內阻增大，輸出電流減小。這時應及時用充電機對蓄電池進行補充充電，直至電解液中產生大量氣泡為止。蓄電池長期停用時應進行定時充電保養，車輛封存期間，蓄電池一般都應統一集中在蓄電池間，由專人負責維護保管。須知，蓄電池都存在一個內部自放電的問題，每天自放電量約2％，因此，蓄電池必須有專人專室保管，定時檢查，每月至少補充充電1次，每次補充充電分2階段完成：第1階段電流以額定容量的10％進行，時間以10小時左右為宜；第2階段充電電流和時間均減半進行。還有，應重視新叉車蓄電池的初充電 新品干荷蓄電池加好電解液半小時后，雖有電流輸出，可直接投入使用，但為有效地提高蓄電池今后的性能和使用壽命，最好進行1次初充電后再使用。同樣，初充電也分為2階段來完成：第1階段電流以額定容量的5％進行，時間為30小時左右；第2階段充電電流減半進行，時間為25小時左右。檢查保養時，嚴格按操作規程進行 平時在檢查維護保養時，絕對禁止用金屬絲或金屬棒來測量電解液液面，也不要隨便將扳手、螺絲刀等金屬工具放在蓄電池上，否則很容易造成蓄電池短路。另外，在采用多塊串聯式蓄電池組進行充電或使用時，盡量用容量相同的蓄電池進行串聯，切勿采取容量大、小或新、舊搭配的方法使用，因不同容量的蓄電池串聯時，容量小的會處于過充電或過放電狀態，造成極板活性物質脫落；容量大的則會充電不足，造成極板硫化，容量下降。